DC/DC Converter Performance
The P0A94 code means the vehicle's onboard diagnostic system has detected: DC/DC Converter Performance. This is a critical severity code.
- Keep driving?
- No — stop driving
- DIY difficulty
- hard
- Estimated cost
- $200 - $5,000 (12-volt battery or coolant service at the low end; inverter assembly with converter at the high end)
Best-selling code reader on Amazon. Reads and clears check engine codes on any 1996+ vehicle. Under $30.
Essential for diagnosing sensor codes, checking voltage, and testing circuits. Under $15 and pays for itself on the first job.
Affiliate links — we earn a commission at no extra cost to you.
Common Symptoms
- Check Engine Light on
- Hybrid system warning light or red triangle
- 12-volt battery warning, or the car dying after a short drive
- Vehicle may enter limp mode or refuse to start
- Multiple electrical systems misbehaving at once
Probable Causes (Ranked by Likelihood)
- Failure inside the inverter assembly with converter - intelligent power module (IPM), MG ECU, or internal harness (Toyota T-SB-0003-21) Very High
- Inverter coolant loss, air in the inverter cooling loop, or a failed inverter coolant pump causing thermal shutdown High
- Degraded 12-volt battery loading the converter beyond its output Moderate
- Damaged wiring or connector between the converter and the 12-volt system Low
Frequently Asked Questions
What does P0A94 mean?
P0A94 means the DC/DC converter is not performing as expected. That converter steps high-voltage battery power down to charge the 12-volt battery and run normal vehicle electronics, so when it fails the whole low-voltage side of the car starves.
Why did my car die if the hybrid battery is fine?
Because the 12-volt battery is what wakes and runs the control modules, and the DC/DC converter is what keeps it charged. With the converter down, the car runs on whatever the 12-volt battery holds and then stops - even with a healthy high-voltage pack.
Is P0A94 always an expensive inverter repair?
Not always. Check the cheap causes first: a worn 12-volt battery, low inverter coolant, or a failed inverter coolant pump can all produce this complaint. Toyota's bulletin does point at the inverter assembly with converter for the covered Prius models, and that repair is expensive, so confirm the detail code before committing.
Is P0A94 safe to work on myself?
This code involves the high-voltage system. Do not open the HV battery, inverter, or any orange-cabled component without hybrid-specific training, insulated gloves, and the service plug removed. Inspection of the cabin-side cooling intake is the one part most owners can safely do themselves.
Mechanics Guide Step-by-step diagnosis
Step-by-Step Diagnostic Procedure
-
Scan for companion codes. Toyota T-SB-0003-21 covers P0A94 together with P324E, P0A1A, and P3004, and uses the detail code to decide which internal part is at fault.
-
Measure 12-volt system voltage with the hybrid system running - the DC/DC converter is what charges the 12-volt battery, so low or absent charging voltage confirms the complaint.
-
Check the inverter coolant level and confirm the inverter coolant pump runs; overheating from a dry or airlocked loop is a repairable cause that mimics converter failure.
-
Load-test the 12-volt battery and replace it if weak before condemning the converter.
-
Inspect the converter output wiring and connectors for damage or corrosion.
Sources 2
This page is built from documented references. Verify against your own service info before repair work.
- Toyota T-SB-0003-21 (Jan 12, 2021), 'MIL ON With DTCs P0A94, P324E, P0A1A, and/or P3004' - attributes P0A94 to a malfunction in the inverter assembly with converter on 2010-2015 Prius and 2012-2017 Prius V, diagnosed by detail code to isolate the IPM, MG ECU, or wire harness.
- SAE J2012Diagnostic Trouble Code Definitions (defines the generic OBD-II code ranges)
Commonly Affected Vehicles
- 2010-2015 Toyota Prius (subject of Toyota T-SB-0003-21)
- 2012-2017 Toyota Prius V (subject of Toyota T-SB-0003-21)
- 2015-2017 Acura TLX
- Toyota Camry Hybrid and Highlander Hybrid
Related Codes
Explore More
Was this helpful?
Send this to whoever is fixing the car — your mechanic, or the person asking what the light means.